Abstract

This study investigates the optimum operating conditions and design configurations that can optimize the power reclaimed by small hydro turbines derived by the rising water-bubble current. The rising current is generated by the compressed air introduced by the diffusers at the bottom of aeration basins of wastewater treatment plants (WWTPs). While optimizing the power production, the standard oxygen transfer efficiency (SOTE) is monitored since it is a significant parameter that cannot be sacrificed in the operation of WWTPs. Using one set of turbine blades, it was found out that the highest velocity is obtained in the upper half of the water column (70—80%). In contrast, the lowest velocities were obtained just above the air diffuser and at the water surface. Testing started with using a single turbine (ST) to determine the location of the optimum power reclaimed at each tested airflow (1.18, 1.42, 1.65, and 1.89 L/s). Then, using double turbine (DT) and triple turbine (TT) to compare their performance to the ST’s maximum power increased power reclamation. The maximum percentage of increase in power reclamation for DT is 19.59%, while it is 20.24% in the case of TT. At a commonly used airflow in WWTPs (1.42 L/s), the optimum configurations of DTs and TTs were selected to investigate the effect of having the proposed setup on the SOTE. For membrane diffusers, DTs and TTs limited the dispersion of the air bubbles in the tank, therefore reducing the SOTE (8.3% for DT and 3.7% for the TT). The ceramic and sharp-nub diffusers were also tested versus rubber membrane ones to determine the effect of using the ceramic and sharp-nub diffusers on the power reclamation and SOTE. Ceramic diffusers neither achieve higher power reclamation than the membrane nor increase the SOTE. In contrast, sharp-nub diffusers increase the SOTE for all configurations compared to membranes, but this came into account of power reclamation, where sharp-nub diffusers cause a DT and a TT to produce less power than ST does.

Issue Section:
Energy Systems Analysis
Keywords:
alternative energy sources, energy conversion/systems, energy systems analysis, power (co-) generation, renewable energy
Topics:
Air flow, Bubbles, Diffusers, Hydraulic turbines, Membranes, Oxygen, Turbines, Water, Sensors, Ceramics, Compressed air

References

1.
Municipal Resource Recovery Design Committee
,
2017
, “
Liquid Stream Fundamentals: Aeration Design
,” Water Environment Federation.
2.
Al Babaa
,
H.
,
El Gammal
,
T.
, and
Amano
,
R.
,
2016
, “
Correlations of Bubble Diameter and Frequency for Air–Water System Based on Orifice Diameter and Flow Rate
,”
ASME J. Fluids Eng.
,
138
(
11
), p.
114501
.
3.
Alkhalidi
,
A.
, and
Amano
,
R.
,
2015
, “
Factors Affecting Fine Bubble Creation and Bubble Size for Activated Sludge
,”
Water Environ. J.
,
29
(
1
), pp.
105
–
113
.
4.
Al Babaa
,
H.
,
Prada
,
M.
,
Olson
,
C.
,
Alkhalidi
,
A.
,
Amano
,
R.
, and
Li
,
J.
,
2014
, “
An Experimental Study of Reducing Back Pressure of Fine Air Diffuser Used in Wastewater Plants
,”
Proceedings of ASME 2014 Fluids Engineering Summer Meeting
, p.
V01CT16A006
, Paper No. FEDSM2014-21203.
5.
Amano
,
R.
,
Abbas
,
A.
,
Al Haddad
,
M.
, and
Qandil
,
M.
,
2019
, “
Energy Consumption, Energy-Saving and Emissions Reduction of Wastewater Treatment Plants (WWTPs) in Wisconsin
,”
AIAA Propulsion and Energy 2019 Forum
,
Indianapolis, IN
,
Aug. 19–22
.
6.
“
Energy and the Environment
,” United States Environmental Protection Agency, https://www.epa.gov/energy/greenhouse-gases-equivalencies-calculator-calculations- and-references, Accessed 29 June 2020.
7.
Amano
,
R.
,
Alkhalidi
,
A.
, and
Al Babaa
,
H.
,
2014
, “
Reducing the Space and Power Consumption for Aerospace Water Treatment by Improving Aeration Process Using Innovative Mixing Power Reclamation Device
,”
Proceedings of AIAA SciTech 2014
,
National Harbor, MD
.
8.
Amano
,
R.
, and
Alkhalidi
,
A.
,
2012
, “
Design of a Deflector for Water Aeration in Wastewater Treatment
,”
Proceedings of ASME 2012
,
Houston, TX
.
9.
Amano
,
R.
, and
Alkhalidi
,
A.
,
2012
, “
Water Aeration in Wastewater Treatment
,”
Proceedings of ASME 2012 DETC/CIE, DETC2012-71524
,
Chicago, IL
.
10.
Abbas
,
A.
,
Qandil
,
M.
,
Al Haddad
,
M.
,
Saravani
,
M.
, and
Amano
,
R.
,
2019
, “
Utilization of Hydro-Turbines in Wastewater Treatment Plants
,”
ASME J. Energy Resour. Technol.
,
141
(
6
), p.
062011
.
11.
Abbas
,
A.
,
Qandil
,
M.
,
Al Haddad
,
M.
, and
Amano
,
R.
,
2020
, “
Investigation of Micro Kaplan Hydro-Turbine Performance Using Multi-Disciplinary Optimization
,”
ASME J. Energy Resour. Technol.
,
142
(
5
), p.
052101
.
12.
United States, Environmental Protection Agency
,
2004
,
Primer for Municipal Wastewater Treatment Systems
,
Office of Water, Office of Wastewater Management
,
Washington, DC
.
13.
Alkhalidi
,
A.
, and
Amano
,
R.
,
2012
, “
Bubble Deflector to Enhance Fine Bubble Aeration for Wastewater Treatment in Space Usage
,”
Proceedings of the 50th AIAA Aerospace Sciences Meeting Including the New Horizons Forum and Aerospace Exposition
,
Nashville, TN
.
14.
Amano
,
R.
, and
Alkhalidi
,
A.
,
2010
, “
Study of Air Bubble Formation Process in Aeration System
,”
Proceedings of ASME 2010 10th Biennial Conference on Engineering Systems Design and Analysis, ESDA2010-24045
,
Istanbul, Turkey
.
15.
Miletta
,
B.
,
Alkhalidi
,
A.
, and
Amano
,
R.
,
2011
, “
Study of Enhanced Aeration System
,”
Proceedings of the 9th AIAA JPC/IECEC
,
San Diego, CA
.
16.
Amano
,
R.
,
Alkhalidi
,
A.
,
Miletta
,
A.
, and
Li
,
J.
,
2011
, “
Study of Air Bubble Formation for Wastewater Treatment
,”
ASME DETC/CIE, Paper No. DETC2011-47065
,
Washington, DC.
17.
Abbas
,
A.
,
Al Haddad
,
M.
,
Qandil
,
M.
,
Saravani
,
M.
, and
Amano
,
R.
,
2019
, “
Optimization of Kaplan Hydro-Turbine at Very Low Head With Rim-Driven Generator
,”
ASME J. Energy Resour. Technol.
,
141
(
11
), p.
111204
.
18.
Qandil
,
M.
,
Abbas
,
A.
,
Abdelhadi
,
A.
,
El Gammal
,
T.
, and
Amano
,
R.
,
2020
, “
The Cavitation Characteristics That Occurs Over a Hydrofoil in a Water Tunnel
,”
Fluids Engineering Division’s (FED) Summer Meeting, FEDSM2020
,
Orlando, FL
.
19.
Hasan
,
A.
,
Salem
,
A.
,
Abdel Hadi
,
A.
,
Qandil
,
M.
,
Amano
,
R.
, and
Alkhalidi
,
A.
,
2021
, “
The Power Reclamation of Utilizing Micro-hydro Turbines in the Aeration Basins of Wastewater Treatment Plants
,”
ASME J. Energy Resour. Technol.
,
143
(
8
), p.
081301
.
20.
Qandil
,
M.
,
Abbas
,
A.
,
Abdelhadi
,
A.
,
Salem
,
A.
, and
Amano
,
R.
,
2021
, “
Energy Analysis: Ways to Save Energy and Reduce the Emissions in Wastewater Treatment Plants
,”
Int. J. Energy Clean Environ.
,
22
(
1
), pp.
91
–
112
.
21.
Nourin
,
F.
,
Abbas
,
A.
,
Qandil
,
M.
, and
Amano
,
R.
,
2021
, “
Analytical Study to Use the Excess Digester Gas of Wastewater Treatment Plants
,”
ASME J. Energy Resour. Technol.
,
143
(
1
), p.
012104
.
22.
O'Connor
,
K.
, and
Torrey
,
D.
,
2011
,
Hydropower From Wastewater
,
New York State Energy Research and Development Authority
,
Albany, NY
.
23.
2017
,
Water and Wastewater Treatment Energy Savings Guide
,
Energy Trust of Oregon
,
Portland, OR
.
24.
2020
,
Water & Wastewater Industry Energy Best Practices Guidebook
,
Wisconsin Focus on Energy
.
25.
Amano
,
R.
,
Espindola
,
J.
,
Nourin
,
F.
,
Qandil
,
M.
, and
Abdelhadi
,
A.
,
2020
, “
Energy Saving Analysis Using Energy Intensity Usage and Specific Energy Consumption Methods
,”
Int. J. Energy Clean Environ.
,
22
(
1
), pp.
15
–
29
.
26.
Qandil
,
M.
,
Abbas
,
A.
,
El Gammal
,
T.
,
Abdelhadi
,
A.
, and
Amano
,
A.
,
2021
, “
Water Energy Resource Innovation on the Cavitation Characteristics
,”
ASME J. Energy Resour. Technol.
,
143
(
2
), p.
022106
.
27.
Selim
,
O.
,
Abousabae
,
M.
,
Hasan
,
A.
, and
Amano
,
R.
,
2021
, “
Analysis of Energy Savings and CO2 Emission Reduction Contribution for Industrial Facilities in USA
,”
ASME J. Energy Resour. Technol.
,
143
(
8
), p.
082303
.
28.
Abbas
,
A.
,
Al Haddad
,
M.
,
Saravani
,
M.
, and
Amano
,
R.
,
2018
, “
Net-Zero-Energy Wastewater Treatment Plants
,”
AIAA Aerospace Sciences Meeting
,
Kissimmee, FL
.
29.
Al Haddad
,
M.
,
Saravani
,
M.
,
Abbas
,
M.
, and
Amano
,
R.
,
2018
, “
An Analytical Study of Energy Efficiency Opportunities in Some Industrial Facilities
,”
AIAA Aerospace Sciences Meeting
,
Kissimmee, FL
.
30.
Al Haddad
,
M.
,
Abbas
,
A.
,
Saravani
,
M.
, and
Amano
,
R.
,
2018
, “
Net-Zero-Energy (NZE) Wastewater Treatment Plants (WWTPs)
,”
AIAA SciTech Forum
,
Kissimmee, FL
.
31.
Al Haddad
,
M.
,
Saravani
,
M.
,
Abbas
,
A.
, and
Amano
,
R.
,
2017
, “
Energy Efficiency Opportunities in Some Industrial Facilities
,”
IMECE2017-72792
,
Tampa, FL
.
32.
Qandil
,
M.
,
Abbas
,
A.
,
Al Haddad
,
M.
, and
Amano
,
R.
,
2019
, “
Energy Consumption, Energy Saving and Emissions Reduction of Wastewater Treatment Plants in Wisconsin
,”
AIAA Propulsion and Energy Forum
,
Indianapolis, IN
.
33.
Amano
,
R.
, and
El Gammal
,
T.
,
2019
, “
Study of a Cavitation Treatment in Kaplan Hydro Turbine
,”
AIAA Propulsion and Energy, AIAA-2019-4408
,
Indianapolis, IN
.
34.
Amano
,
R.
,
Qandil
,
M.
,
Abbas
,
A.
, and
Al Haddad
,
M.
,
2019
, “
Performance Investigation of Very-Low-Head Kaplan Hydro-Turbines
,”
AIAA SciTech, AIAA-2019-0241
,
San Diego, CA
.
35.
Amano
,
R.
,
Qandil
,
M.
,
Abbas
,
A.
, and
Abdelhadi
,
A.
,
2019
, “
Study of Cavitation Phenomena Over the Hydrofoil of Hydro Turbines
,”
AIAA SciTech, AIAA-2019-0783
,
San Diego, CA
.
36.
Abbas
,
A.
,
Qandil
,
M.
, and
Amano
,
R.
,
2020
, “
Optimization of Computational Fluid Dynamics Simulations for Hydro Turbines Applications
,”
FEDSM2020-12653, 2020 Fluids Engineering Division’s (FED) Summer Meeting
,
Orlando, FL
.
37.
Qandil
,
M.
,
Abbas
,
A.
,
Salem
,
A.
,
Abdelhadi
,
A.
,
Hasan
,
A.
,
Nourin
,
F.
,
Abousabae
,
M.
,
Selim
,
O.
,
Espindola
,
J.
, and
Amano
,
R.
,
2021
, “
Net Zero Energy Model for Wastewater Treatment Plants
,”
ASME J. Energy Resour. Technol.
,
143
(
12
), p.
122101
.
38.
Alkhalidi
,
A.
,
Amano
,
R.
, and
Khawaja
,
M.
,
2019
, “
Estimation Model of KLa Constant Using Bubble Release Rate and Bubble Size
,”
Sch. J. Eng. Tech.
,
7
(
2
), pp.
33
–
40
.
39.
Alkhafaji
,
A.
,
Alkhalidi
,
A.
, and
Amano
,
R.
,
2016
, “
Effect of Water Column Height on the Aeration Efficiency Using Pulsating Airflow
,”
Jordan J. Mech. Ind. Eng.
,
10
(
2
), pp.
45
–
50
. https://www.researchgate.net/publication/327307908_Effect_of_Water_Column_Height_on_the_Aeration_Efficiency_Using_Pulsating_Air_Flow
40.
Alkhalidi
,
A.
,
Al Babaa
,
H.
, and
Amano
,
R.
,
2016
, “
Wave Generation in Subsurface Aeration System: A New Approach to Enhance Mixing in Aeration Tank in Wastewater Treatment
,”
Desalin. Water Treat.
,
57
(
56
), pp.
27144
–
27151
.
41.
Amano
,
R.
, and
Alkhafaji
,
A.
,
2020
, “
Evaluation of Ceramic and Membrane Diffusers Under Different Water Columns With Pulsating Air Flow Method
,”
Int. J. Energy Clean Environ.
, pp.
145
–
167
.
42.
Amano
,
R.
,
Alkhafaji
,
A.
, and
Alkhalidi
,
A.
,
2017
, “
Study of Aeration by Using Pulsating Air Flow
,”
AIAA SciTech Forum
,
Grapevine, TX
.
43.
Amano
,
A.
, and
Alkhafaji
,
A.
,
2020
, “
Experimental and Computational Study on the Effect of Diffusion Order in Aeration Systems
,”
Int. J. Energy Clean Environ.
,
21
(
3
), pp.
221
–
236
.
44.
Alkhalidi
,
A.
,
Bryar
,
P.
, and
Amano
,
R.
,
2016
, “
Improving Mixing in Water Aeration Tanks Using Innovative Self-Powered Mixer and Power Reclamation From Aeration Tank
,”
Jordan J. Mech. Ind. Eng.
,
10
(
3
), pp.
211
–
214
.
45.
Selim
,
O.
, and
Amano
,
R.
,
2021
, “
Co-Pyrolysis of Chicken and Cow Manure
,”
ASME J. Energy Resour. Technol.
,
143
(
1
), p.
011301
.
46.
Selim
,
O.
,
Hussein
,
M.
, and
Amano
,
R.
,
2020
, “
Effect of Heating Rate on Chemical Kinetics of Chicken Manure With Different Gas Agents
,”
ASME J. Energy Resour. Technol.
,
142
(
10
), p.
102104
.
47.
Espindola
,
J.
,
Selim
,
O.
, and
Amano
,
R.
,
2021
, “
Co-Pyrolosis of Rice Husk and Chicken Manure
,”
ASME J. Energy Resour. Technol.
,
143
(
2
), p.
022101
.
48.
Pawlak-Kruczek
,
H.
,
Krochmalny
,
K.
,
Wnukowski
,
M.
, and
Niedzwiecki
,
L.
,
2018
, “
Slow Pyrolysis of Sewage Sludge With Additives: Calcium Oxide and Lignite
,”
ASME J. Energy Resour. Technol.
,
140
(
6
), p.
062206
.
49.
Pawlak-Kruczek
,
H.
,
Wnukowski
,
M.
,
Krochmalny
,
K.
,
Kowal
,
M.
,
Baranowski
,
M.
,
Zgora
,
J.
,
Czerep
,
M.
,
Ostrycharczyk
,
M.
, and
Niedzwiecki
,
L.
,
2019
, “
The Staged Thermal Conversion of Sewage Sludge in the Presence of Oxygen
,”
ASME J. Energy Resour. Technol.
,
141
(
7
), p.
070701
.
50.
Diaz
,
L.
,
Savage
,
G.
,
Trezek
,
G.
, and
Golueke
,
C.
,
1981
, “
Biogasification of Municipal Solid Wastes
,”
ASME J. Energy Resour. Technol.
,
103
(
2
), pp.
180
–
185
.
51.
Dinc
,
G.
,
Isik
,
F.
, and
Yel
,
E.
,
2020
, “
Effects of Pyrolysis Conditions on Organic Fractions and Heat Values of Olive Mill Wastes Pyrolysis Liquid
,”
ASME J. Energy Resour. Technol.
,
142
(
10
), p.
102107
.
52.
Ren
,
H.
,
Jiang
,
N.
,
Wang
,
T.
,
Omar
,
M.
,
Ruan
,
W.
, and
Ghafoor
,
A.
,
2018
, “
Enhanced Biogas Production in the Duckweed Anaerobic Digestion Process
,”
ASME J. Energy Resour. Technol.
,
140
(
4
), p.
041805
.
53.
Sunyoto
,
N.
,
Zhu
,
M.
,
Zhang
,
Z.
, and
Zhang
,
D.
,
2018
, “
Effect of Biochar Addition and Temperature on Hydrogen Production From the First Phase of Two-Phase Anaerobic Digestion of Carbohydrates Food Waste
,”
ASME J. Energy Resour. Technol.
,
140
(
6
), p.
062204
.
54.
Yentekakis
,
I.
,
Goula
,
G.
,
Leone
,
P.
, and
Neophytides
,
S.
,
2018
, “
Editorial: Advanced Utilization and Management of Biogas
,”
Front. Environ. Sci.
,
6
, pp.
1
–
3
.
55.
Zhu
,
Y.
,
Somasundaram
,
S.
,
Kemp
,
J.
, and
Zhu
,
Y.
,
2010
, “
Energy and Exergy Analysis of Gasifier-Based Coal-to-Fuel Systems
,”
ASME J. Energy Resour. Technol.
,
132
(
2
), p.
021008
.
56.
Gandiglio
,
M.
,
Lanzini
,
A.
,
Soto
,
A.
,
Leone
,
P.
, and
Santarelli
,
M.
,
2017
, “
Enhancing the Energy Efficiency of Wastewater Treatment Plants Through Co-Digestion and Fuel Cell Systems
,”
Front. Environ. Sci.
,
5
, pp.
1
–
21
.
57.
Tm Series In-Line Torque Transducers
,
Buffalo, NY
:
Magtrol
,
2021
58.
2021
,
Torque Display Model 3411 User's Manual
,
Magtrol
,
Buffalo, NY
.
59.
2016
,
Vernier Optical DO Probe Product Catalogue
,
Vernier Software & Technology
,
Beaverton, OR
.
60.
Amano
,
R.
,
Alkhafaji
,
A.
, and
Al Ba'ba'a
,
H.
,
2016
, “
Wave Generation in Subsurface Aeration Systems–A New Approach to Enhance Mixing in Aeration Tank in Wastewater Treatment
,”
Desalin. Water Treat.
,
57
(
56
), pp.
1
–
8
.
61.
Amano
,
R.
, and
Alkhalidi
,
A.
 “
Membrane for Air Diffusers
,” Milwaukee, WI, US Patent No. US 2013/0099401, 25 April 2013.
Copyright © 2021 by ASME
You do not currently have access to this content.